Effect of Nanocellulose on Phase Behavior of off-Critical PS/PVME Blend

Document Type : Research Paper

Authors

1 Department of Polymer Engineering, Amirkabir University of Technology, P.O. Box: 15875-4413, Tehran, Iran

2 Polymer Engineering Group, Faculty of Engineering, Qom University of Technology, P.O. Box: 37195-1519, Qom, Iran

Abstract

Hypothesis: The influence of hydrophobic nanocellulose on phase separation behavior of off-critical PS/PVME (polystyrene/polyvinyl methyl ether) blends was studied. While the effect of spherical nanoparticles (NPs) on the phase behavior of polymer blends has been previously explored, the impact of rod-like NPs on the phase behavior has not been well studied. Compared to nanospheres, nanorods are associated with much lower critical percolation concentration, due to the high aspect ratio of nanorods.
Methods: For this purpose, neat PS/PVME blends with compositions of 40/60 and 10/90 and in the presence of 2% nanocellulose were investigated. The temperature sweep of storage modulus, from the one-phase region temperature to those higher than the two-phase region temperature, was used to investigate the effect of nanoparticles on phase separation temperature. Phase-contrast optical microscopy (OM) was employed to investigate the morphological evolution of PS/PVME blends during the phase separation. TEM images indicated the localization of hydrophobic nanocellulose in the PS-rich phase which was consistent with the prediction of thermodynamic wetting parameter.
Findings: Viscoelastic phase separation (VPS) controlled the phase behavior of PS/PVME 10/90 blend which in the presence of nanoparticles increased the stability of the PS-rich network structure even at high temperatures. The PS/PVME 40/60 blend was phase separated under the nucleation and growth mechanism (NG), and there was a wide distribution of droplets size in the late stage of phase separation. With increasing the quench depth, the dynamic asymmetry increased, leading to transition of the phase separation mechanism from NG to VPS. The addition of nanoparticles enhanced the dynamic asymmetry which induced the VPS at lower temperatures.

Keywords

References

Zhang J., Ravati S., Virgilio N., and Favis B.D., Ultralow Percolation Thresholds in Ternary Cocontinuous Polymer Blends, Macromolecules, 40, 8817-8820, 2007.
Asadi K., Wondergem H.J., Moghaddam R.S., McNeill C.R., Stingelin N., Noheda B., Blom P.W.M., and de Leeuw D.M., Spinodal Decomposition of Blends of Semiconducting and Ferroelectric Polymers, Adv. Funct. Mater., 21, 1887-1894, 2011.
Xie H.Q., Xu J., and Zhou S., Polymer Blends with Two Kinds of Elastomeric Ionomers, Polymer, 32, 95-102,1991.
Nishi T., Wang T., and Kwei T., Thermally Induced Phase Separation Behavior of Compatible Polymer Mixtures, Macromolecules, 8, 227-234, 1975.
Shin M., Kim H., Park J., Nam S., Heo K., Ree M., Ha C.S., and Kim Y., Abrupt Morphology Change upon Thermal Annealing in Poly(3-hexylthiophene)/Soluble Fullerene Blend Films for Polymer Solar Cells, Adv. Funct. Mater., 20, 748-754, 2010.
Iwashita Y. and Tanaka H., Self-organization in Phase Separation of a Lyotropic Liquid Crystal into Cellular, Network and Droplet Morphologies, Nature Mater., 5, 147-152, 2006.
Tanaka H., Universality of Viscoelastic Phase Separation in Dynamically Asymmetric Fluid Mixtures, Phys. Rev. Lett., 76, 787, 1996.
Hoppe H. and Sariciftci N.S., Morphology of Polymer/Fullerene Bulk Heterojunction Solar  Cells, J. Mater. Chem., 16, 45-61, 2006.
Liu Z., Maréchal P., and Jérôme R., Blends of Poly(vinylidene fluoride) with Polyamide 6: Interfacial Adhesion, Morphology and Mechanical Properties, Polymer, 39, 1779-1785, 1998.
Yeganeh J.K., Goharpey F., Moghimi E., Petekidis G., and Foudazi R., Controlling the Kinetics of Viscoelastic Phase Separation Through Self-Assembly of Spherical Nanoparticles or Block Copolymers, Soft Matter, 10, 9270-9280, 2014.
Barham B., Fosser K., Voge G., Waldow D., and Halasa A., Phase Separation Kinetics of a Polymer Blend Modified by Random and Block Copolymer Additives, Macromolecules, 34, 514-521, 2001.
Pu G., Luo Y., Wang A., and Li B., Tuning Polymer Blends to Cocontinuous Morphology by Asymmetric Diblock Copolymers as the Surfactants, Macromolecules, 44, 2934-2943, 2011.
Foudazi R. and Nazockdast H., Rheology and Morphology of Nanosilica-containing Polypropylene and Polypropylene/Liquid Crystalline Polymer Blend, J. Appl. Polym. Sci., 128, 3501-3511, 2013.
Liu X.Q., Li R., Bao R., Jiang W., Yang W., Xie B., and Yang M., Suppression of Phase Coarsening in Immiscible, Co-continuous Polymer Blends under High Temperature Quiescent Annealing, Soft Matter, 10, 3587-3596, 2014.
Gharachorlou A. and Goharpey F., Rheologically Determined Phase Behavior of LCST Blends in the Presence of Spherical Nanoparticles, Macromolecules, 41, 3276-3283, 2008.
Xavier P. and Bose S., Non-equilibrium Segmental Dynamics Driven by Multiwall Carbon Nanotubes in PS/PVME Blends, Phys. Chem. Chem. Phys., 16, 9309-9316, 2014.
Xavier P., Bharati A., Madras G., and Bose S., An Unusual Demixing Behavior in PS–PVME Blends in the Presence of Nanoparticles, Phys. Chem. Chem. Phys., 16, 21300-21309, 2014.
Yeganeh J.K., Goharpey F., Moghimi E., Petekidis G., and Foudazi R., Manipulating the Kinetics and Mechanism of Phase Separation in Dynamically Asymmetric LCST Blends by Nanoparticles, Phys. Chem. Chem. Phys., 17, 27446-27461, 2015.
Xavier P. and Bose S., Mapping the Intriguing Transient Morphologies and the Demixing Behavior in PS/PVME Blends in the Presence of Rod-Like Nanoparticles, Phys. Chem. Chem. Phys., 17, 14972-14985, 2015.
Xavier P., Sharma K., Elayarajaa K., Vasub K.S., Soodb A.K., and Bose S., Reduced Graphene Oxide Induced Phase Miscibility in Polystyrene-Poly(vinyl methyl ether) Blends, RSC Adv., 4, 12376-12387, 2014.
Vleminckx G., Bose S., Leys J., Vermant J., Wübbenhorst M., Abdala A.A., Macosko C., and Moldenaers P., Effect of Thermally Reduced Graphene Sheets on the Phase Behavior, Morphology, and Electrical Conductivity in Poly[(α-methyl styrene)-co-(acrylonitrile)/Poly(methyl-methacrylate) Blends, ACS Appl. Mater. Int., 3, 3172-3180, 2011.
Xavier P. and Bose S., Multiwalled-Carbon-Nanotube-Induced Miscibility in Near-Critical PS/PVME Blends: Assessment Through Concentration Fluctuations and Segmental Relaxation,  J. Phys. Chem. B, 117, 8633-8646, 2013.
Habibi Y., Lucia L.A., and Rojas O.J., Cellulose Nanocrystals: Chemistry, Self-Assembly, and Applications, Chem. Rev., 110, 3479-3500, 2010.
Eichhorn S.J., Cellulose Nanowhiskers: Promising Materials for Advanced Applications, Soft Matter, 7, 303-315, 2011.
Roohani, M., Habibi Y., Belgacem N.M., Ebrahim G., Karimi A.N., and Dufresn A , Cellulose Whiskers Reinforced Polyvinyl Alcohol Copolymers Nanocomposites, Eur. Polym. J., 44, 2489-2498, 2008.
Hubbe M.A., Rojas O.J., Lucia L.A., and Sain M., Cellulosic Nanocomposites: A Review, BioResources, 3, 929-980, 2008.
Bai H., Zhou Y., and Zhang L., Morphology and Mechanical Properties of a New Nanocrystalline Cellulose/Polysulfone Composite Membrane, Adv. Polym. Technol., 34, 2015.
Khademzadeh Yeganeh J., Goharpey F., and Foudazi R., Rheology and Morphology of Dynamically Asymmetric LCST Blends: Polystyrene/Poly(vinyl methyl ether), Macromolecules, 43, 8670-8685, 2010.
Kalia S., Dufresne A., Cherian B.M., and Kaith B.M., Cellulose-based Bio- and Nanocomposites: A Review,  J. Polym. Sci., 2011, 2011.
Sun B., Zhang M., Hou Q., Liu R., Wu T., and Si C., Further Characterization of Cellulose Nanocrystal (CNC) Preparation from Sulfuric Acid Hydrolysis of Cotton Fibers, Cellulose, 23 439-450, 2016.
El Mabrouk K. and Bousmina M., Effect of Hydrodynamics on Dynamics of Phase Separation in Polystyrene/Poly(vinyl methyl ether) Blend, Polymer, 46, 9005-9014, 2005.
Reich S. and Cohen Y., Phase Separation of Polymer Blends in Thin Films, J. Polym. Sci., Polym. Phys. Ed., 19, 1255-1267, 1981.
Polios I.S., Soliman M., Lee C., Gido S.P., and Schmidt-Rohr K., Late Stages of Phase Separation in a Binary Polymer Blend Studied by Rheology, Optical and Electron Microscopy, and Solid State NMR., Macromolecules, 30, 4470-4480, 1997.
Li L.., Miesch C., Sudeep P.K., Balazs A.C., and Emrick T., Kinetically Trapped Co-continuous Polymer Morphologies Through Intraphase Gelation of Nanoparticles, Nano letters, 11, 1997-2003, 2011.
Ajji A. and Choplin L., Rheology and Dynamics Near Phase Separation in a Polymer Blend: Mmodel and Scaling Analysis, Macromolecules, 24, 5221-5223, 1991.
Fredrickson G.H. and Larson R.G., Viscoelasticity of Homogeneous Polymer Melts Near a Critical Point, J. Chem. Phys., 86, 1553-1560, 1987.
Tanaka H., Formation of Network and Cellular Structures by Viscoelastic Phase Separation, Adv. Matt., 21, 1872-1880, 2009.
Tanaka H., Viscoelastic Phase Separation, J. Phys: Cond. Matt.,  12, 207, 2000.
Zou F., Dong X., Liu W., Yang J., and Lin D., Shear Induced Phase Boundary Shift in the Critical and Off-critical Regions for a Polybutadiene/Polyisoprene Blend, Macromolecules, 45, 1692-1700, 2012.
Koyama T., Araki T., and Tanaka H., Fracture Phase Separation, Phys. Rev. Lett., 102, 065701, 2009.
Koyama T. and Tanaka H., Generic Kinetic Pathway of Phase Separation of Deeply Quenched Polymer Solutions: Transient Gelation, EPL (Europhysics Letters), 80, 68002, 2007.
Lifshitz I.M. and Slyozov V.V., The Kinetics of Precipitation from Supersaturated Solid Solutions, J. Phys. Chem. Solids, 19, 35-50, 1961.
Binder K. and Stauffer D., Theory for the Slowing Down of the Relaxation and Spinodal Decomposition of Binary Mixtures, Phys. Rev. Lett., 33, 1006, 1974.
Tanaka H., New Coarsening Mechanisms for Spinodal Decomposition Having Droplet Pattern in Binary Fluid Mixture: Collision-induced Collisions, Phys. Rev. Lett .,72, 1702, 1994.
Tanaka H., New Mechanisms of Droplet Coarsening in Phase-Separating Fluid Mixtures, J. Chem. Phys., 107, 3734-3737, 1997.
Vander Linden C. and Van Leemput R., Adsorption Studies of Polystyrene on Silica I. Monodisperse Adsorbate, J. Colloid. Int. Sci., 67, 48-62, 1978.
Owens D.K. and Wendt R., Estimation of the Surface Free Energy of Polymers, J. Appl. Polym. Sci., 13, 1741-1747, 1969.
Stöckelhuber K.W., Das A., Jurk R., and Heinrich G., Contribution of Physico-chemical Properties of Interfaces on Dispersibility, Adhesion and Flocculation of Filler Particles in Rubber, Polymer, 51, 1954-1963, 2010.
Tanaka H. and Nishi T., Anomalous Phase Separation Behavior in a Binary Mixture of Poly(vinyl methyl ether) and Water Under Deep Quench Conditions, in Dynamics and Patterns in Complex Fluids, Dynamics and Patterns in Complex Fluids, 119-120, 1990.
Tanaka H., Appearance of a Moving Droplet Phase and Unusual Networklike or Spongelike Patterns in a Phase-Separating Polymer Solution with a Double-Well-Shaped Phase Diagram, Macromolecules, 25, 6377-6380, 1992.
Gibbs J.H. and DiMarzio E.A., Nature of the Glass Transition and The Glassy State, J. Chem. Phys., 28, 373-383, 1958.
Kar G.P., Xavier P., and Bose S., Polymer-grafted Multiwall Carbon Nanotubes Functionalized by Nitrene Chemistry: Effect on Cooperativity and Phase Miscibility. Phys. Chem. Chem. Phys., 16, 17811-17821, 2014.
Kar G.P., Bharati A., Xavier P., and Madras G., The Key Role of Polymer Grafted Nanoparticles in the Phase Miscibility of an LCST Mixture, Phys. Chem. Chem. Phys., 17, 868-877, 2015.
Donth E., The Size of Cooperatively Rearranging Regions at the Glass Transition, J. Non-Crystal. Solid., 53, 325-330, 1982.

Iranian Journal of Polymer Science and Technology
Volume 30, Issue 6 - Serial Number 152
January and February 2018
Pages 531-545

Files

Share

How to cite

Statistics